Jump to content

Johnstown Inclined Plane

Coordinates: 40°19′32″N 78°55′43″W / 40.32556°N 78.92861°W / 40.32556; -78.92861
From Wikipedia, the free encyclopedia
(Redirected from Johnstown Inclined Railway)

40°19′32″N 78°55′43″W / 40.32556°N 78.92861°W / 40.32556; -78.92861

Johnstown Inclined Plane
Overview
LocaleJohnstown, Pennsylvania
United States
Transit typeFunicular
Annual ridership63,764 (2017) Decrease 2.3%
Websitewww.inclinedplane.org
Official nameJohnstown Inclined Railway
DesignatedJune 18, 1973
Reference no.73001597[1]
ArchitectSamuel Diescher
Official nameJohnstown Incline
DesignatedSeptember 1994
Reference no.180[2]
Operation
Began operationJune 1, 1891 (1891-06-01)
Operator(s)CamTran
Technical
System length896.5 ft (273.3 m)
Track gauge8 ft (2,440 mm)

The Johnstown Inclined Plane is a 896.5-foot (273.3 m) funicular in Johnstown, Cambria County, Pennsylvania, U.S. The incline and its two stations connect the city of Johnstown, situated in a valley at the confluence of the Stonycreek and the Little Conemaugh rivers, to the borough of Westmont on Yoder Hill. The Johnstown Inclined Plane is billed as the "world's steepest vehicular inclined plane". It can carry automobiles and passengers, up or down a slope with a grade of 71.9%.[2][3] The travel time between stations is 90 seconds.

After a catastrophic flood in 1889, the Johnstown Inclined Plane was completed in 1891 to serve as an escape route from floods in the valley, as well as a convenient mode of transportation for residents of the new communities above the valley. It was operated by Cambria Iron Company and its successor Bethlehem Steel until 1935, when it was sold to the borough of Westmont. The incline was briefly shut down in 1962 when its supply of power from Bethlehem Steel was terminated.

Twice in its history, the Johnstown Inclined Plane fulfilled its role as a means of evacuation from floods—once in 1936 and again in 1977. The incline was listed on the National Register of Historic Places in 1973 and was designated a Historic Mechanical Engineering Landmark in 1994. It had major renovations in 1962 and from 1983 to 1984. It closed for a further renovation in 2021.

Design

[edit]

The Johnstown Inclined Plane was designed by Hungarian-American engineer Samuel Diescher, who had also designed the Duquesne, Castle Shannon and Fort Pitt Inclines in Pittsburgh.[4] The funicular consists of a parallel set of 8 ft (2,440 mm) broad gauge railroad tracks with a 70.9% grade or an angle of 35 degrees and 28 minutes from the horizontal.[5][A] The incline is 896.5 feet (273.3 m) long and ascends 502.2 feet (153.1 m) vertically to the top of Yoder Hill and the borough of Westmont, the station of which is at an elevation of 1,693.5 feet (516.2 m) above sea level.[5]

The rails are supported by 720 14-foot-long (4 m) railroad ties made from Southern Yellow Pine.[5] The incline is illuminated at night by 114 high-pressure sodium-vapor lamps mounted along the sides of tracks.[5] There was a stairway between the tracks with 966 steps; this was removed c. 1963.[6]

Two cars traverse the slope; as one descends, the other ascends and acts as a counterweight. The cars are 15 feet 6 inches (4.7 m) wide, 15 feet 2 inches (4.6 m) tall, and 34 feet (10 m) long, and are large enough to carry either 65 people, 6 motorcycles, or an automobile.[7] While the cars are open to the elements, an enclosed seating area with a bench is situated along the outer side of the incline.[3] The cables connecting the cars are 2-inch-diameter (50.8 mm), 6×36 right regular lay, steel wire rope. They are wound around a 3-short-ton (2.7-metric-ton; 2.7-long-ton), 16-foot-diameter (5 m) drum that connects the cars. The cable on the north track is 1,075 feet (328 m) long, while the south cable is 7 feet (2.13 m) shorter. Each car weighs 22 short tons (20.0 metric tons; 19.6 long tons), but they and the cables can carry an additional load of 15 short tons (13.6 metric tons; 13.4 long tons). A 400-horsepower (298 kW) electric motor drives the drum, simultaneously winding and unwinding the cable, to propel the incline. The Johnstown Inclined Plane is unusual in that the motor and winch are located at a 90-degree angle to the incline instead of directly underneath it.[8] Operation of the incline is controlled via a foot pedal located in a booth in the upper station.[9]

An emergency brake engages if the air pressure needed to control the incline is insufficient; the brake also engages if a dead man's switch is tripped in the operator's booth.[9] In addition to the hauling cables, a 972-foot (296 m) safety cable capable of withstanding 165 short tons (149.7 metric tons; 147.3 long tons) is also connected to the cars.[5][10]

  • The room that houses the incline's hoisting mechanisms
    The room that houses the incline's hoisting mechanisms
  • The upper station has an observation deck and visitor center/restaurant adjacent to it
    The upper station has an observation deck and visitor center/restaurant adjacent to it
  • The enclosed passenger area, with bench.
    The enclosed passenger area, with bench.
  • The main deck of the car, which is large enough to hold several motorcycles or an automobile.
    The main deck of the car, which is large enough to hold several motorcycles or an automobile.

History

[edit]

Background and construction

[edit]

Inclines are common in Europe, and immigrants, like the German, Slavic, and Welsh people who settled near Johnstown, remembered them from their native lands and brought the concept to the United States.[4] The earliest inclines in the United States were a series of 10 that were built in the 1830s as part of the Allegheny Portage Railroad.[11] The portage railroad carried canal boats over the Allegheny Mountains to connect the canals from Pittsburgh to the ones from Philadelphia. Pittsburgh at one time also had "at least 17" inclines—some carried passengers, others freight, while another two inclines (like the Nunnery Hill Incline) were curved.[11]

On May 31, 1889, the South Fork Dam collapsed upstream of Johnstown on the Little Conemaugh River. The resulting deluge devastated the city, killing 2,209 people.[3] As the city rebuilt, the Cambria Iron Company started work on a residential development atop Yoder Hill.[12] To provide easy transportation on the steep slope for residents of the new community of Westmont, the company constructed an inclined plane. In addition to being a convenient mode of transportation, the Johnstown Inclined Plane doubled as an escape route in event of flood. Diescher was hired by Cambria Iron to design the incline. The rails used in the incline were manufactured in Johnstown at Cambria Iron, and many of the construction tools handcrafted there.[13] The 232-foot (71 m) Inclined Plane Bridge was built to span the Stoneycreek River to provide access to the lower station of the incline. Originally named the Cambria Inclined Plane, the Johnstown Inclined Plane opened on June 1, 1891, and cost $133,296 to build.[12]

1890s to 1960s

[edit]

The convenience the incline provided stimulated a rapid growth of population in Westmont and made the borough one of the country's first suburbs.[12][13] Over 40 million trips were taken on the incline in its first 80 years of operation.[12][14] The incline's original steam engine was disconnected on January 6, 1912, and replaced with an electric motor.[15] The cars used on the incline were originally double-deckers, but were reconfigured into a single-decker design in 1921. The double-decker cars had horses and wagons riding on the main, upper deck and passengers riding in a compartment below.[13] Only one human fatality has occurred at the incline; it was determined that the incident was not caused by the incline itself.[16] There were two incidents in the 1920s when horses aboard the incline became spooked and leapt from the car onto the tracks.[9] Bethlehem Steel, the successor to Cambria Iron, sold the Johnstown Inclined Plane to the borough of Westmont in April 1935.[13]

On March 17, 1936, nearly 4,000 people were evacuated from Johnstown to higher ground via the incline as the Stoneycreek and Conemaugh Rivers overflowed their banks.[9] The floodwaters continued downstream and eventually reached Pittsburgh. From February 1938 to July 1953, the Johnstown Traction Company operated transit buses from Johnstown to Westmont with the "fully loaded public buses" being carried by the incline.[9][17] Bethlehem Steel stopped supplying electricity to the Johnstown Inclined Plane when the factory switched to "an incompatible power system", forcing the incline to close on January 31, 1962.[18] Because of public pressure to keep the incline operating, it was reopened in July 1962 after extensive renovation, in which the electric motor was rewound, ties were replaced, and the cars were repainted.[9][13]

1970s to 2010s

[edit]

The Johnstown Inclined Plane was listed on the National Register of Historic Places on June 18, 1973.[1] On July 20, 1977, the incline was again used as an escape route, evacuating residents from the valley amid rising floodwaters. It also carried "boats, emergency personnel, and equipment down to the valley to aid in rescue operations".[13] The incline was closed for repairs in January 1983,[19][20] at which point the renovation was planned to cost $1.7 million.[20] The incline was again sold for $1 by Westmont borough on March 8, 1983, to the Cambria County Transit Authority, now CamTran.[13] CamTran initiated a $4.2 million renovation on September 7, 1983, replacing steel, foundation piers and track.[21] The federal government funded 80% of the renovation, while the local government provided the remainder.[22] The renovations were completed on August 22, 1984, and the incline was rededicated on September 6.[2] The Pittsburgh Press wrote at the time: "For Johnstown, the incline has, in more ways than one, provided a lift."[14]

The incline was designated an Historic Mechanical Engineering Landmark by the American Society of Mechanical Engineers (ASME) in September 1994.[2] A footbridge spanning Pennsylvania Route 56 between the incline and Vine Street was opened around the same time.[23] On September 1, 2000, the incline was closed when the Pennsylvania Department of Transportation (PennDOT) undertook an $2.3 million renovation of the bridge and its access road.[24] It was reopened in April 2001, but again closed in September to allow PennDOT to finish repairs to the bridge deck. The repairs were completed on December 14, 2001.[24] A strong thunderstorm disrupted power to the incline on April 16, 2010, stranding the cars and two passengers almost halfway down the slope. The rescue took three hours, and ended when firefighters rappelled down the tracks to reach the car.[25]

The Johnstown Inclined Plane was closed from September 9 to October 14, 2010, for the installation of a new 9,000-pound (4,100 kg) "hoist brake shaft."[26] From October 29 to 31, 2012, CamTran shut down the incline fearing power outages due to the passage of Hurricane Sandy.[27] During the annual Thunder in the Valley motorcycle rally, two resistors failed and stopped the incline near the stations on June 28, 2014. Repairs took approximately a month after consultants diagnosed the failure.[28] Sensor issues briefly disrupted service in August 2014, and again in December 2014, forcing the incline to start its winter maintenance period early.[28]

  • Side view
    Side view
  • Two cars traversing the slope

2020s refurbishment

[edit]

In 2021, the incline closed for a renovation, which was expected to cost more than $12 million.[29] The refurbishment included restoration of the cars, a complete overhaul of the mechanical and electrical systems, and replacement of all the track ties.[30][29] The project was funded by a variety of state and federal grants—including a $24.4 million grant from the federal government[31][32]—and donations from local foundations.[29][33] By July 2022, the incline's ties had been replaced, a drainage system had been added, and vegetation had been planted around the incline.[33]

Though the project was supposed to be completed in early 2023,[34] the renovation stalled after work was 92 percent complete.[35][36] Local TV station WJAC-TV reported in May 2023 that the incline's reopening had delayed due to issues in completing and delivering the sheave wheels, to which the cables are attached.[37] After further issues arose that November, CamTran halted the renovation entirely in January 2024.[38][39] The sheave wheels had to be remade after they were delivered.[40] In addition, officials discovered damage to one of the cables, and the incline needed to be inspected and recertified before it could reopen.[41] In May 2024, CamTran awarded three contracts for the renovation of the incline's visitor center, its observation deck, and a footbridge at the bottom of the incline.[41] Due to the continued delays, CamTran declined to review bids for replacement cables that September, as the cables were not ready to be installed.[42] Work resumed in December 2024 after CamTran finished investigating the cable damage; at the time, the incline was scheduled to reopen in 2025.[34][43]

Current operations

[edit]

With the growing usage of the automobile and construction of new roads, ridership on the incline diminished. It was losing $25,000 a year by 1961.[9] Since the 1980s, the incline has become one of the main tourist attractions in Johnstown, with people visiting the incline to "ride for fun, nostalgia and novelty."[3] Primarily used for tourism, the incline's use by commuters, who bike or walk to work, has also increased.[44] CamTran's Route 18 transit bus offers connections between the incline and downtown Johnstown.[45] As of 2017, the cost for a ride on the incline is $3 or $5 for a roundtrip. The one way fare for automobiles $8.[46] The incline takes around 90 seconds to travel between stations. The same trip takes 10 minutes by automobile.[9] In 2021, the Johnstown Inclined Plane had an annual ridership of 20,193 passengers, a decrease of 50.5 percent from the previous year.[47]

The upper station has a gift shop selling souvenirs and snacks. A visitor center is located adjacent to the station.[46] The mechanical room housing the incline's hoisting mechanism can be viewed from windows in the gift shop and the visitor center lobby.[46] An observation deck providing views of the incline, the city, and the valley is located on the opposite side of the station from the visitor center.[46] Since the 1970s, the upper station of the Johnstown Incline has also led to a series of multipurpose trails.[30] Two hiking trails and several mountain bike trails allow visitors to recreate on the hillside. One of the hiking trails is a sculpture trail, with works created in 1989 by local artist James Wolfe, who used remnants of the Bethlehem Steel factory in Johnstown.[48]

Panorama from the observation deck at the top of the incline. The Little Conemaugh River (center-left) and the Stonycreek River (right) combine in Johnstown to form the Conemaugh River.

See also

[edit]

Explanatory notes

[edit]
A. ^ Various other sources often use 71.9 percent as the grade of the incline.[9]

Citations

[edit]
  1. ^ a b "Johnstown Inclined Railway". NPSGallery. National Park Service. Retrieved July 9, 2020.
  2. ^ a b c d "#180 Johnstown Incline (1891)". American Society of Mechanical Engineers. Retrieved May 21, 2017.
  3. ^ a b c d Wiseman, Lisa (December 23, 2004). "Johnstown's Inclined Plane is steeped in history, tragedy". The Baltimore Sun. Archived from the original on June 29, 2011. Retrieved January 7, 2011.
  4. ^ a b Forte 1994, p. 3.
  5. ^ a b c d e The Historic Johnstown Inclined Plane Technical Guide. CamTran.
  6. ^ Moser, Nick (January 17, 1963). "The Passing Parade". Reading Eagle. p. 8. Retrieved January 7, 2011.
  7. ^ "Welcome to the Johnstown Inclined Plane". Johnstown Inclined Plane. Retrieved January 7, 2011.
  8. ^ Forte 1994, p. 2.
  9. ^ a b c d e f g h i Maurer, Chris (October 1, 1967). "A Lofty Look at Johnstown". The New York Times. p. XX11.
  10. ^ Pennsylvania Historic Sites and Landmarks 1972, § 7.
  11. ^ a b Fountain 2007, p. F6.
  12. ^ a b c d Pennsylvania Historic Sites and Landmarks 1972, § 8, p. 1.
  13. ^ a b c d e f g Forte 1994, p. 1.
  14. ^ a b "The Johnstown incline". The Pittsburgh Press. September 12, 1984. p. 28. Retrieved December 9, 2024.
  15. ^ Springirth 2006, p. 110.
  16. ^ Pennsylvania Historic Sites and Landmarks 1972, § 8, pp. 1–2.
  17. ^ Springirth 2006, p. 116.
  18. ^ "Johnstown Incline ceases to operate". Reading Eagle. Associated Press. February 1, 1962. Retrieved January 8, 2011.
  19. ^ Dvorchak, Bob (April 10, 1983). "113-year-old Pittsburgh incline proves it's not over the hill". The Arizona Republic. Associated Press. p. 184. Retrieved December 9, 2024.
  20. ^ a b "Pennsylvania city closes its century-old railway". The Miami Herald. United Press International. January 9, 1983. p. 746. Retrieved December 9, 2024.
  21. ^ Springirth 2006, p. 112.
  22. ^ "Specter backs incline funds". Latrobe Bulletin. United Press International. May 2, 1984. p. 36. Retrieved December 9, 2024.
  23. ^ Springirth 2006, p. 113.
  24. ^ a b Springirth 2006, p. 118.
  25. ^ Potts, Ted (April 17, 2010). "Hour of havoc". The Tribune-Democrat. Johnstown, Pennsylvania. Retrieved February 11, 2011.
  26. ^ Faher, Mike (October 14, 2010). "Incline reopening following repairs". The Tribune-Democrat. Johnstown, Pennsylvania. Retrieved January 13, 2011.
  27. ^ Griffith, Randy (October 29, 2012). "Rescue icon idled as storm nears". The Tribune-Democrat. Johnstown, Pennsylvania. Retrieved March 16, 2014.
  28. ^ a b Griffith, Randy (January 30, 2015). "CamTran extends winter break for Inclined Plane". The Tribune-Democrat. Johnstown, Pennsylvania. Retrieved February 9, 2015.
  29. ^ a b c Griffith, Randy (March 28, 2021). "Overhaul will idle Inclined Plane for two summers". The Tribune-Democrat. Retrieved December 7, 2024.
  30. ^ a b Stabert, Lee (June 30, 2021). "Along for the Ride: An ambitious plan lifts a Johnstown institution to the top". Keystone Edge. Retrieved December 7, 2024.
  31. ^ Mamula, Kris B. (March 18, 2023). "'Johnstown is having a moment': $24.4 million federal grant will kick-start city revival, officials say". Pittsburgh Post-Gazette. Retrieved December 7, 2024.
  32. ^ Slusser, Thomas (November 20, 2021). "Johnstown's $24M transportation grant is state's biggest winner". The Tribune-Democrat. Retrieved December 7, 2024.
  33. ^ a b Slusser, Thomas (July 23, 2022). "CamTran: Inclined Plane work still on schedule for '23 reopening". The Tribune-Democrat. Retrieved December 7, 2024.
  34. ^ a b Berkey, Todd (November 28, 2024). "Inclined Plane rehab to restart Monday". The Tribune-Democrat. Retrieved December 7, 2024.
  35. ^ Owens, Brock (September 23, 2024). "Still no timeline for reopening of Johnstown Inclined Plane". WJAC. Retrieved December 7, 2024.
  36. ^ Berkey, Todd (July 19, 2024). "CamTran: Engineer to review 'action plan' to repair, restart idled Inclined Plane". The Tribune-Democrat. Retrieved December 7, 2024.
  37. ^ "Johnstown delays re-opening of Inclined Plane due to late parts delivery". WJAC. May 24, 2023. Retrieved December 7, 2024.
  38. ^ "Construction paused on Johnstown Inclined Plane project, officials announce". WJAC. January 31, 2024. Retrieved December 7, 2024.
  39. ^ Berkey, Todd (February 1, 2024). "Inclined Plane work stops while efforts underway to ID, solve issue". The Tribune-Democrat. Retrieved December 7, 2024.
  40. ^ Berkey, Todd (October 26, 2024). "Plan in works to repair, reinstall Inclined Plane 'sheave wheels,' CamTran says". The Tribune-Democrat. Retrieved December 7, 2024.
  41. ^ a b Berkey, Todd (May 7, 2024). "Johnstown Inclined Plane to remain shut down through 2024". The Cumberland Times-News. Retrieved December 7, 2024.
  42. ^ Owens, Brock (September 23, 2024). "Still no timeline for reopening of Johnstown Inclined Plane". WJAC. Retrieved December 7, 2024.
  43. ^ "Johnstown Inclined Plane Construction Resumes". FOX8. December 3, 2024. Retrieved December 7, 2024.
  44. ^ Griffith, Randy (April 20, 2009). "Inclined Plane kicks off summer commuter hours". The Tribune-Democrat. Johnstown, Pennsylvania. Retrieved January 8, 2011.
  45. ^ "Route 18 Downtown Shuttle". CamTran. Retrieved November 17, 2015.
  46. ^ a b c d "Visitor Information". Johnstown Inclined Plane. Retrieved June 25, 2017.
  47. ^ "Service Data and Operating Expenses Time-Series by Mode" (XLSX). National Transit Database. Federal Transit Administration. 2021. Unlinked Passenger Trips. TS2.1. Retrieved April 23, 2023.
  48. ^ Springirth 2006, p. 111.

General sources

[edit]
[edit]
Wikimedia Commons has media related to Johnstown Inclined Plane.

Retrieved from "https://wiki.riteme.site/w/index.php?title=Johnstown_Inclined_Plane&oldid=1262182871"