Jump to content

Republic XF-84H Thunderscreech

From Wikipedia, the free encyclopedia
(Redirected from Republic XF-106)
XF-84H "Thunderscreech"
Propeller-driven fighter with undercarriage extended
XF-84H serial number 51-17060 in flight, with the ram air turbine extended
General information
TypeExperimental fighter
National originUnited States
ManufacturerRepublic Aviation
Primary userUnited States Air Force
Number built2
History
First flight22 July 1955
Developed fromRepublic F-84F Thunderstreak

The Republic XF-84H "Thunderscreech" is an American experimental turboprop aircraft derived from the F-84F Thunderstreak. Powered by a turbine engine that was mated to a supersonic propeller, the XF-84H had the potential of setting the unofficial air speed record for propeller-driven aircraft, but was unable to overcome aerodynamic deficiencies and engine reliability problems, resulting in the program's cancellation.[1] Its name, Thunderscreech, is a reference to its extremely loud supersonic propeller.

Design and development

[edit]

Although the USAF Wright Air Development Center was the key sponsor of the Republic Project 3347 turboprop fighter, the initial inception came from a U.S. Navy requirement for a carrier fighter not requiring catapult assistance.[2] Originally known as XF-106 (a designation later reused for the Convair F-106),[3] the project and its resultant prototype aircraft were redesignated XF-84H,[4] closely identifying the program as an F-84 variant, rather than an entirely new type.[5] With a projected contract for three prototypes, when the US Navy canceled its order, ultimately, the remaining XF-84H prototypes became pure research aircraft built for the Air Force's Propeller Laboratory at Wright-Patterson AFB to test supersonic propellers in exploring the combination of propeller responsiveness at jet speeds.[6]

The XF-84H was created by modifying a F-84F Thunderstreak airframe, installing a 5,850 hp (4,360 kW) XT40-A-1 turboprop engine[7] in a centrally-located housing behind the cockpit with a long extension shaft to the nose-mounted propeller.[8] The turbine engine also provided thrust through its exhaust; an afterburner which could further increase power to 7,230 hp (5,390 kW) was installed but never used.[9] Thrust was adjusted by changing the blade pitch of the 12 ft (3.7 m) diameter Aeroproducts propeller, consisting of three steel, square-tipped blades turning at a constant speed, with the tips traveling at approximately Mach 1.18 (1,446 km/h). To counter the propeller's torque and "P-factor", the XF-84H was fitted with a fixed dorsal yaw vane.[10] The tail was changed to a T-tail to avoid turbulent airflow over the horizontal stabilizer/elevator surfaces from propeller wash.[11]

The XF-84H was destabilized by the powerful torque from the propeller, as well as inherent problems with supersonic propeller blades.[12] A number of exotic blade configurations were tested before settling on a final design.[10] Various design features were intended to counteract the massive torque, including mounting the left leading edge intake 12 in (30 cm) further forward than the right, and providing left and right flaps with differential operation.[8] The two prototypes were equally plagued with engine-related problems affecting other aircraft fitted with T40 engines, such as the Douglas A2D Skyshark and North American XA2J Super Savage attack aircraft. A notable feature of the design was that the XF-84H was the first aircraft to carry a retractable/extendable ram air turbine. In the event of engine failure, it would automatically swing out into the airstream to provide hydraulic and electrical power. Due to frequent engine problems, as a precaution, the unit was often deployed in flight.[10]

Testing

[edit]
Prototype 51-17059

After manufacture at Republic's plant in Farmingdale, Long Island, the two XF-84Hs were disassembled and shipped via rail to Edwards Air Force Base for flight testing.[2] First flown on July 22, 1955, the XF-84H had incredible acceleration but soon its impracticality was discovered. It was unsuited to combat due to the engine's 30-minute warm-up time, but the most serious concerns were vibration generated from the 12-foot diameter propeller and mechanical failures of the prop pitch gearing.[13] The prototypes flew a total of 12 test flights from Edwards, accumulating only 6 hours and 40 minutes of flight time. Lin Hendrix, one of the Republic test pilots assigned to the program, flew the aircraft once and refused to ever fly it again, claiming "it never flew over 450 knots (830 km/h) indicated, since at that speed, it developed an unhappy practice of 'snaking', apparently losing longitudinal stability".[14] Hendrix also told the formidable Republic project engineer, "You aren't big enough and there aren't enough of you to get me in that thing again".[13] The other test flights were fraught with engine failures, and persistent hydraulic, nose gear, and vibration problems.[2] Test pilot Hank Beaird took the XF-84H up 11 times, with 10 of these flights ending in forced landings.[15]

Noise

[edit]

The XF-84H was almost certainly the loudest aircraft ever built, earning the nickname "Thunderscreech" as well as the "Mighty Ear Banger".[16] On the ground "run ups", the prototypes could reportedly be heard 25 miles (40 km) away.[17] Unlike standard propellers that turn at subsonic speeds, the outer 24–30 inches (61–76 cm) of the blades on the XF-84H's propeller traveled faster than the speed of sound even at idle thrust, producing a continuous visible sonic boom that radiated laterally from the propellers for hundreds of yards. The shock wave was actually powerful enough to knock a man down; an unfortunate crew chief who was inside a nearby C-47 was severely incapacitated during a 30-minute ground run.[17] Coupled with the already considerable noise from the subsonic aspect of the propeller and the T40's dual turbine sections, the aircraft was notorious for inducing severe nausea and headaches among ground crews.[11] In one report, a Republic engineer suffered a seizure after close range exposure to the shock waves emanating from a powered-up XF-84H.[18]

The pervasive noise also severely disrupted operations in the Edwards AFB control tower by risking vibration damage to sensitive components and forcing air traffic personnel to communicate with the XF-84H's crew on the flight line by light signals. After numerous complaints, the Air Force Flight Test Center directed Republic to tow the aircraft out on Rogers Dry Lake, far from the flight line, before running up its engine.[14] The test program did not proceed further than the manufacturer's Phase I proving flights; consequently, no USAF test pilots flew the XF-84H. With the likelihood that the engine and equipment failures coupled with the inability to reach design speeds and subsequent instability experienced were insurmountable problems, the USAF canceled the program in September 1956.[19]

Historical significance

[edit]
See also: Fastest propeller-driven aircraft
Prototype 51-17059

Although The Guinness Book of World Records recorded the XF-84H as the fastest propeller-driven aircraft ever built,[20][failed verification] with a design top speed of 670 mph (1,080 km/h) (Mach 0.9) and 623 mph (1,003 km/h) (Mach 0.83) during tests, this claim has been disputed.[14]

The unofficial record speed is also inconsistent with data from the National Museum of the United States Air Force, which gives a top speed of 520 mph (840 km/h) (Mach 0.70), nonetheless, making the XF-84H the fastest single-engine propeller-driven aircraft[11] until 1989 when "Rare Bear", a highly modified Grumman F8F Bearcat, reached 528 mph (850 km/h) (Mach 0.71).[21]

Operators

[edit]
 United States
  • United States Air Force: The prototypes never flew in USAF pilots' hands, as they only completed the initial manufacturer's flight tests.
Republic XF-84H in the Research & Development Gallery at the National Museum of the U.S. Air Force, Dayton, Ohio.

Aircraft disposition

[edit]

Two prototypes were built (51-17059 and 51-17060), with buzz numbers FS-059 and FS-060.[22]

Specifications

[edit]
The first XF-84H on display in Bakersfield

General characteristics

  • Crew: 1
  • Length: 51 ft 5 in (15.67 m)
  • Wingspan: 33 ft 5 in (10.18 m)
  • Height: 15 ft 4 in (4.67 m)
  • Wing area: 331.0 sq ft (30.75 m2)
  • Empty weight: 17,892 lb (8,132 kg)
  • Gross weight: 27,046 lb (12,293 kg)
  • Powerplant: 1 × Allison XT40-A-1 turboprop, 5,850 hp (4,365 kW)

Performance

  • Maximum speed: 520 mph (837 km/h, 450 kn)
  • Range: 2,000 mi (3,200 km, 1,700 nmi)
  • Service ceiling: 40,000 ft (14,600 m)
  • Rate of climb: 5,000 ft/min (25 m/s)
  • Thrust/weight: 0.66

See also

[edit]

Related development

Aircraft of comparable role, configuration, and era

Related lists

References

[edit]

Notes

[edit]
  1. ^ Knaack, Marcelle Size. Encyclopedia of U.S. Air Force Aircraft and Missile Systems: Volume 1 Post-World War II Fighters 1945–1973. Washington, D.C.: Office of Air Force History, 1978. ISBN 0-912799-59-5.
  2. ^ a b c Keaveney 1987, p. 9.
  3. ^ Heyman, Jos and Andreas Parsch. "Duplications in U.S. Military Aircraft Designation Series". designations-systems.net, 2004. Retrieved: 17 July 2010.
  4. ^ Holder 2006, p. 18.
  5. ^ Keaveney 1987, p. 27.
  6. ^ Wilkinson 2003, pp. 2–3.
  7. ^ "Fact Sheet: Allison T-40-A-10". Nationalmuseum.af.mil, 2 April 2009. Retrieved: 16 July 2017.
  8. ^ a b Winchester 2005, p. 233.
  9. ^ Wilkinson 2003, p. 5.
  10. ^ a b c Keaveney 1987, p. 17.
  11. ^ a b c d "Fact Sheet: XF-84H." Nationalmuseum.af.mil, 26 August 2009. Retrieved: 16 July 2017.
  12. ^ Wilkinson 2003, p. 2.
  13. ^ a b Aviation History magazine Nov 2010, page 19
  14. ^ a b c Hendrix 1977, p. 408.
  15. ^ Wilkinson 2003, p. 4.
  16. ^ Hendrix 1977, p. 406.
  17. ^ a b Wilkinson 2003, p. 1.
  18. ^ Kruszelnicki, Dr. Karl S. "Thunder-Struck." abc.net.au, 11 September 2003. Retrieved: 17 July 2010.
  19. ^ a b Winchester 2005, p. 232.
  20. ^ Young 1997, p. 137.
  21. ^ "Aircraft Speed Records". aerospaceweb.org. Retrieved: 18 July 2010.
  22. ^ Andrade 1979, p. 103.
  23. ^ Jenkins 2008, p. 78.

Bibliography

[edit]
  • Andrade, John M. (1979). U.S. Military Aircraft Designations and Serials Since 1909. Earl Shilton, Leicester, England: Midland Counties Publications. ISBN 0-904597-22-9.
  • Angellucci, Enzo; Peter M. Bowers (1987). The American Fighter: The Definitive Guide to American Fighter Aircraft from 1917 to the Present. New York: Orion Books. ISBN 0-517-56588-9.
  • Bridgman, Leonard, ed. (1956). Jane's All The World's Aircraft 1956–1957. London: Jane's All the World's Publishing Co. Ltd.
  • Davis, Larry; Dave Menard (1983). F-84 Thunderjet in Action. Aircraft in Action. Vol. 61. Carrollton, Texas: Squadron/Signal Publications. ISBN 0-89747-147-4.
  • Hendrix, Lin (August 1977). "Flying the Thunderscreech". Aeroplane Monthly. 5 (8).
  • Holder, Bill (2006). Lost Fighters: A History of U.S. Jet Fighter Programs That Didn't Make It. Warrendale, PA: SAE International. ISBN 978-0768017120.
  • Jenkins, Dennis R.; Tony Landis (2008). Experimental and Prototype U.S. Air Force Jet Fighters. North Branch, MN: Specialty Press. ISBN 978-1-58007-111-6.
  • Keaveney, Kevin (1987). Republic F-84 (Swept-Wing Variants). Arlington, TX: Aerofax. ISBN 0-942548-20-5.
  • Wilkinson, Stephan (July 2003). "ZWRRWWWBRZR: That's the sound of the prop-driven XF-84H, and it brought grown men to their knees. It didn't fly all that great either". Air & Space/Smithsonian. Washington, D.C.: Smithsonian Institution. Retrieved 2013-10-07.
  • Winchester, Jim (2005). The World's Worst Aircraft: From Pioneering Failures to Multimillion Dollar Disasters. London: Amber Books. ISBN 1-904687-34-2.
  • Young, Mark C., ed. (1997). The Guinness Book of Records 1997. North Salem, NY: Mint Publishers Group. ISBN 0-85112-014-8.
[edit]
Wikimedia Commons has media related to Republic XF-84H Thunderscreech.
Retrieved from "https://wiki.riteme.site/w/index.php?title=Republic_XF-84H_Thunderscreech&oldid=1259546621"