Jump to content

.338 Marlin Express

Edit links
From Wikipedia, the free encyclopedia
(Redirected from .338 Marlin express)

.338 Marlin Express
.308 Winchester (left), with .308 Marlin Express (center), and .338 Marlin Express (right)
TypeRifle
Place of originUS
Production history
DesignerMarlin / Hornady
Designed2009
ManufacturerHornady
Produced2009–2019
Specifications
Parent case.376 Steyr
Case typeSemi-rimmed, bottleneck
Bullet diameter.338 in (8.6 mm)
Neck diameter.372 in (9.4 mm)
Shoulder diameter.496 in (12.6 mm)
Base diameter.502 in (12.8 mm)
Rim diameter.548 in (13.9 mm)
Rim thickness.045 in (1.1 mm)
Case length1.886 in (47.9 mm)
Overall length2.583 in (65.6 mm)
Rifling twist1:12 in (300 mm)
Primer typeWLR
Maximum pressure (SAAMI)46,500 psi (321 MPa)
Ballistic performance
Bullet mass/type Velocity Energy
200 gr (13 g) FTX (Hornady Flex Tip Expanding) (BC: .430) 2,565 ft/s (782 m/s) 2,922 ft⋅lbf (3,962 J)
Test barrel length: 24 in (610 mm)
Source(s): 338 Marlin Express LEVERevolution at Hornady web site & MidwayUSA and C.I.P. Data[1]

The .338 Marlin Express is a cartridge developed by Marlin Firearms and Hornady. It is based on the .376 Steyr with a goal to duplicate the venerable .30-06 Springfield's performance in a cartridge compatible with lever-action firearms. The cartridge uses a slightly shorter, rimmed case to function in lever-action rifles with tubular magazines. As introduced in Hornady's LEVERevolution line of cartridges, it follows the design logic of the .308 Marlin Express which preceded it. The .338MX fires heavier .338 caliber bullets than the .308 Marlin Express at roughly the same velocity. It is chambered in Marlin's Model 338MX and 338MXLR rifles using the Marlin Model 336 action.[2][3]

Design History and Cartridge Performance

[edit]

Whereas the .308 Marlin Express began by modifying the .307 Winchester, Hornady and Marlin engineers started with a previous collaboration between Hornady and the Austrian arms maker Steyr, the .376 Steyr, when designing the .338 Marlin Express. The case of the .376 Steyr was given a thicker web for added strength, then necked down to .338. The .308 Marlin Express, on the other hand, was made with a thinner web than its parent case, the .307 Winchester, for additional capacity. Although the thicker case webbing reduced capacity, new powders allow the .338 Marlin Express to achieve velocities similar to the .338 Federal with significantly lower pressures. Hornady engineers then looked to the projectile for the new cartridge. They settled on the 200-grain .338 projectile from their .338 Winchester Magnum line. The existing bullet was remade with a thinner jacket in order to promote expansion and upset at longer ranges. This 200-grain .338" projectile is able to impart significantly more energy than the 160 gr projectile used in the .308 Marlin Express, despite similar muzzle velocities. Furthermore, the projectile's high ballistic coefficient allows the .338 Marlin Express to maintain velocity to greater distances than big bore lever cartridges such as .45-70, .444 Marlin, or even the high performance .450 Marlin. Although the heavy bullet weight of these cartridges allow them more muzzle energy, the ballistic advantage of the .338 Marlin Express's projectile begins to show beyond 100 yards. After that point the .338 Marlin Express's projectile retains more energy than even the .450 Marlin. Like the .308 Marlin Express, the .338 Marlin Express was designed to be a relatively flat shooting cartridge, taking advantage of the bullets Hornady designed for the rounds. Its trajectory is similar to the .30-06 Springfield.[4] Since the acquisition of Marlin by Ruger,[5] regular production of .338 Marlin Express ammunition by Hornady has ceased.[citation needed]

Comparison

[edit]
The .338 Marlin Express has a larger diameter than its .308 companion.

The .338 Marlin Express was designed to produce performance similar to the .30-06 Springfield. This would give lever-action hunters improved performance over their .30-30 Winchester rounds. The table below shows how the rounds compare. Reloading data for 200-grain (13 g) bullets for some of the cartridges is not available. Extensive loading data for the .338 Marlin Express is not yet available. The powder used in the Hornady loading is also not yet commercially available as of Feb '09. This round was designed with an elastomer tip, so that the .338 projectile would be safe for use in the tubular magazines of lever-action rifles. Traditional spitzer bullets are not compatible with the tubular magazines. This is due to the danger of the hard, pointed bullet-tip igniting the primer of the round in front of it under recoil impulse. The softer tip eliminates the hazards of stacking pointed rounds end to end in a tubular magazine.[citation needed]

.338 Marlin Express quick comparison
Cartridge Bullet Weight (gr) Muzzle velocity(ft/s) Muzzle energy(ft-lbf) BC Velocity (ft/s)/Energy (ft-lbf) @ 400yds
.338 Marlin Express 200 2565 2922 .430 1820/1471
.308 Marlin Express 160 2660 2513 [6] ? 1836/1197
.30-30 Winchester 160 2300 1880 [7]
.30-06 Springfield 200 2542 2879 [8]
.30-06 Springfield 200 2625 3061 [9]
.376 Steyr (Parent Cartridge) 210 3011 4229
Other comparable cartridges and loadings
Cartridge Bullet Weight (gr) Muzzle velocity(ft/s) Muzzle energy(ft-lbf) BC Velocity (ft/s)/Energy (ft-lbf) @ 400yds
.307 Winchester 150gr 2693 2416 [10]
.300 Savage 150gr FMJ 2765 2547 [11]
.308 Winchester 150gr FMJ 2809 2629 [12]
.308 Winchester 180gr Nos AccuBond 2550 2598 [13]
.30-06 Springfield 150gr FMJ 2900 2820
.30-06 Springfield 200gr SP 2542 2879 [8]
.30-06 Springfield 200gr OPP 2625 3061 [9]
.325 WSM 200gr Accubond CT 2950 3866
.338 Federal 210gr Nos Part 2630 3226
.338-06 A-Square 200 2773 3414 .430 ± 2200/1800[14]
.338-06 A-Square 225 2678 3582 .500 ± 2200/2000[14]
.338-06 A-Square 250 2531 3555 .650 ± 2300/2000[14]
.338 Winchester Magnum 200gr SP 2950 3866
.340 Weatherby Magnum 200gr SP 3221 4607
.348 Winchester 200gr 2530 2840
.35 Remington 200gr Lead Flat Nose 2084 1929
.358 Winchester 200gr SP 2500 2776
.35 Whelen 200gr 2798 3478
9.3x62mm Mauser 231 gr Oryx 2600 3550

See also

[edit]

References

[edit]
  1. ^ C.I.P. 338 Marlin Express (online-PDF 39,6 KB)
  2. ^ "308 Marlin Express at Marlin web site". Archived from the original on December 24, 2006. Retrieved February 21, 2009.
  3. ^ Zwoll, W. van. (2011, January 4). All aboard the .338 Marlin Express. RifleShooter. https://www.rifleshootermag.com/editorial/ammunition_rs_338_122008wo/84273
  4. ^ "All Aboard the .338 Marlin Express" article in Peterson's Rifle Shooter Magazine
  5. ^ "Sturm, Ruger & Company, Inc. Completes the Acquisition of Marlin Assets". Business Wire. November 24, 2020. Archived from the original on September 26, 2023.
  6. ^ "308 Marlin Express LEVERevolution". Hornady. Archived from the original on August 12, 2007. Retrieved February 21, 2009.
  7. ^ "The .30-30 Winchester" by Chuck Hawks.
  8. ^ a b "Lapua Mega Ammunition 30-06 Springfield 200 Grain Soft Point Box of 20". MidwayUSA. Archived from the original on October 7, 2009. Retrieved February 21, 2009.
  9. ^ a b "Norma Ammunition 30-06 Springfield 200 Grain Oryx Protected Point Box of 20". MidwayUSA. Archived from the original on October 7, 2009. Retrieved February 21, 2009.
  10. ^ ".307 Winchester" (PDF). Accurate Powder. Archived from the original (PDF) on September 28, 2007. Retrieved November 26, 2018.
  11. ^ ".300 Savage" (PDF). Accurate Powder. Archived from the original (PDF) on September 30, 2007. Retrieved February 21, 2009.
  12. ^ ".308 Winchester" (PDF). Accurate. Archived from the original (PDF) on September 28, 2007. Retrieved November 26, 2018.
  13. ^ "Black Hills Gold Ammunition 308 Winchester 180 Grain Nosler AccuBond Box of 20". MidwayUSA. Archived from the original on April 17, 2009. Retrieved February 21, 2009.
  14. ^ a b c https://loaddata.com/Cartridge/338-06-Hodgdon-Data/7254
[edit]
Retrieved from "https://wiki.riteme.site/w/index.php?title=.338_Marlin_Express&oldid=1258386892"